Solar Water Heater Maintenance Checklist

Drain the water from the hot water pipe.

Solar water heater maintenance checklist.

Preventing scaling and corrosion. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater. Satisfactory not satisfactory 2 quantity of hot water supply. Check to make sure the water to the hot water heater has been completely shut off.

Use a solution of dish soap and warm. If water is milky drain entire tank. Also read your owner s manual. If it is then you are set to refill the tank.

Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Be sure to check the water draining out and make sure it is clear. Here are some suggested inspections of solar system components. Two major factors affecting the performance of properly sited and installed solar.

Drain 2 3 gallons of water. If that is too. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Turn off cold water supply and open drain valve.

Turn off the heat. When calling for assistance please have the following. Satisfactory not satisfactory 3 constant temperature e g. Solar water heating system maintenance and repair periodic inspection list.

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Let the water run until it stops flowing. Disconnect the hot water heater at the hot water discharge. Before you begin inspect all of the valves.

Close drain valve and open cold water supply valve. Open a hot water. Regularly scheduled maintenance should include. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel.

1 temperature of hot water. Open t p relief valve to relieve pressure. Whether the tank is gas or electric turn off its heating source the night before. Solar hot water heaters are no different except that because they have more components there is more that can go wrong.

Install pump onto the water heater discharge using pipe fitting.